Problems coal slant fin galaxy fired boiler gas boiler gas coal problems are: 1, more coal ash, 2, unevenness of coal particles, 3, coal contains a large amount of impurities, 4, a lower heating value of coal, 5 when combustion is not easy to ignite fire, 6, coal moisture content uncertain. 7, does not burn coal, slag high carbon content. In general, use is preferably designed coal boiler design coal or coal close, in order to ensure stable combustion. In recent years due to the growing tension surrounding the coal supply, coal supply has become diversified, coal quality is very different than before coal, have a great impact on the stability of the boiler combustion and normal heating operation. Impact of coal combustion boiler stable for: calorific value of coal is coal reflects an important indicator of good or bad, when the low calorific value of coal to a certain value, will not only affect the incomplete combustion instability and can lead boiler flameout, the outlet temperature of the boiler is difficult to compliance, affecting the normal operation. Volatile combustion and can be deposited at lower temperatures, as the combustion heat, the temperature rapidly increased coke particles, provide an extremely favorable conditions for ignition and combustion, volatiles further increased coke deposition and internal voids and the external reaction area, will help improve the speed of burning coke. Thus, the greater the content of volatile, nonflammable, the less fixed carbon in the coal component, the easier coal burning ember, devolatilization of many voids, increases the surface area of ​​the reaction, the combustion reaction is accelerated. When the volatile content is reduced, pulverized coal ignition temperature significantly increased, the hot increases, difficult fire, ignition time required becomes longer, the combustion stability is reduced, shifting the center of the flame, furnace absorbed radiation heating surface reduce heat, increase the heat absorption of the convection heating surface, the rear exhaust temperature, exhaust loss increases.

Wuhan Port District Social Welfare Institute (apartments for the elderly) is invested by the government pension services, with a total construction area of ​​38,000 square meters, 532 beds, mainly adopt destitute persons, social support on behalf of the elderly. Hope to provide welfare to the elderly year-round 24-hour hot water, the original slant fin galaxy fired boiler equipment can not meet this demand, therefore, require additional purchase orphanage hot water boiler. After much investigation, in cooperation with the welfare determined fast boiler, provides three integrally condensing gas hot water boiler (WNS1.4-1.0 / 95/70-Y.Q) by a fast boiler.

Problematic fired slant fin galaxy fired boiler (1) Henan small boiler gas boiler should be noted, by the Henan coal into gas boiler, i.e. the original becomes a negative pressure is now slightly positive pressure combustion burner, the furnace must be noted that the structure and the sealing wall problem; (2) prevent explosion of the furnace, a gas fired boiler furnace to Henan, when defective or incomplete combustion of fuel atomization gas in the furnace or heating surface of the end aggregate, fire or explosion occurs, and therefore, in appropriate sites shall boiler explosion vent means, while the control program should be added to the ignition and flame protection device of automatic control, to ensure safe operation of the boiler; (3) the selection and arrangement of the burner close to the furnace in the form of, should the flame in the furnace better fullness without forming dead air; adjacent flame of the burner to avoid mutual interference; low load flame holding in the furnace central position, offset from the center of the furnace to avoid the flame center of symmetry; unburned gas-air mixture is not in contact with the heated surface , to avoid the formation of incomplete combustion gases; hot flame to avoid high-speed heating surface erosion, in order to avoid excessive heating surface so that the wall strength of overheating. Burner arrangement also consider the gas pipe and duct arrangement, easy to operate, inspection and maintenance; (4) Mechanized layered coal-fired boiler, gas boiler to change Henan, first removing its longitudinal arch, taking into account the increase in the bottom heating surface to replace the grate, grate to prevent overheating burn; (5) gas velocity Henan convection heating surface is not limited by the gas boiler ash abrasion conditions, gas velocity can be increased properly, so the convection heat transfer heating surface coefficient increases, without increasing the heating surface of the boiler, can increase the pressure of the boiler, steam-water separation capability should be noted that at this time means the pot to ensure the quality of steam, hot air for the boiler had particularly important.

For large-scale machinery such as oil and gas slant fin galaxy fired boilers, it is difficult to give an accurate numerical answer if you simply ask how much the boiler price is. In the previous article, we have already introduced that the boiler price calculation will be affected by various factors such as boiler type, brand, structural composition, materials used, and auxiliary machine parts. Therefore, there are still large differences in the price of oil and gas boilers. And the customer's purchase plan is different, the price will also be different.